MK IV Engine Bearings, Valves, Hoses, Gaskets, & Miscellaneous Parts

Printer Friendly Version

Item Number Part Number Illus. # Part Name Description Unit Price
Item Number Part Number Illus. # Part Name Description Unit Price
42 C315,317,3 core plugs for block only (freeze plugs) for set of $12.00
43 C317,343,3 core plugs for head only set of $16.00
44 complete engine core plug set set of 16 set $25.00
49 C339,340 H24-25 cylinder head studs 3½L set of 14 set of $315.00
50 C339,C340 H24,25 individual head studs ea. $35.00
51 C341 H27 chromed head nuts acorn shaped head nut for 3.5 litre 38-51 7/car ea. $17.00
52 note new EMAIL ADDRESS note new EMAIL ADDRESS crnjags@gmail.com new email address crnjags@gmail.com $0.00
54 C379/C561 H62-63 rocker adjustment screw-pin & nut SS-MKIV,V . sold as a set pr. $25.25
55 C412 smaller chromed acorn-shaped nut 3 used on rocker cover, (2 used on trunk lid hinge -MKV only) ea. $14.00
56 C419 H75 fibre gasket on oil filler cap ea. $3.00
57 C428 H32 rectangular front engine mount - used on all SS, MKIV, & early MKV ea. $30.00
62 C462/599 J22-25 crankshaft thrust washers 2 pair per car - sold as a set of 4 only - 2 sizes available - standard or +.005 oversize set $12.00
63 C478 large flat rear engine mount all SS, MKIV, early Mark V ea. $40.00
69 C505 J66 driven gear for distributor drive very limited quantity ea. $75.00
70 C508 H59 rocker shaft for 2½L, 3½L including bronze bushings for rockers and new felt wicks for rockers set $658.00
71 C520 K8 water uptake manifold 3½L MKIV,V ea $550.00
72 C524/C528 H11 gaskets for water pump and pump cover set of 2 set $11.00
75 C531 L29 original style fan belt correct belt! - new lower price ea. $63.00
76 C540 J50 timing chain tensioner spring ea. $67.00
77 C541 J47 bronze finger for timing chain tensioner broken, worn or lost on many cars - takes 2/ engine ea. $72.00
79 C580 A13 2½L chromed acorn shaped head nut ea. $18.00
80 C714 DZ106 radiator filler cap sealing ring (rubber) ea. $3.00
81 C757 J13 woodruff key used in many places including 4 on front of crankshaft ea. $0.95
82 C799 H37-38 drain plug w/copper washer for engine sump pan and transmission ea. $19.00
83 C1022 H74 "JAGUAR" oil filler cap ea $40.00
84 C1022 H74 used "JAGUAR" oil filler cap lots of good used ones ea. $15.00
89 C1434 speedometer cable and sheath complete new unit ea. $27.00
90 C1506 hollow bolt to secure heater pipe brass banjo fitting on water pump.- the one that rusts away! ea. $23.00
91 C1611/1 J34 camshaft timing sprocket for double sprocket timing chain as on SS-MKV $251.00
92 C1612 J15 crankshaft timing sprocket ea. $135.50
93 C1614 J16 double sprocket timing chain SS-MKV ea. $26.00
94 C1715 L34 Fan blade counterbalance pieces ea. $8.00
95 C1782 J32 dowel on outer face of flywheel 2 per car ea $3.00
96 C1788 N3 rubber sealing ring between air cleaner and intake manifold ea. $25.00
100 C2138 H26 3½L plain cylinder head nut under valve cover ea $10.00
102 C2296/1 H38 copper washer on oil sump drain plug C799 ea. $0.95
103 C2361 H58 connecting rod nut steel rods -modern cotterless style ea $4.00
105 C2562 H61-65 3½L pistons with rings and gudgeon pins std. to +.060(not.010) - must be ordered from England -usually in stock in England set of $1,195.00
106 C2565 B57-61 2½L pistons with rings and gudgeon pins std. to +.060(not.010) - must be ordered from England -usually in stock in England set of $1,195.00
110 C2618 H72 3½L rocker cover available new & NOS from England ea. $675.00
123 C3944 connecting rod bolts for steel rods-modern replacement type ea. $9.00
127 C4201 see C338 $0.00
130 1423/A flexible oil pipe SS- MKV ea. $38.00
131 FG.2306 P1 felt oil filter elements MKIV,V- can be reused by washing in solvent ea. $18.00
132 FG.2306P Paper oil filter element ea. $9.00
134 3092 short - & plug side of engine ea. $17.00
135 3204 spark plug wire grommet for inside of above brackets ea. $14.00
775 1431 2 ½, 3 ½L flex fuel line ea. $70.00
777 C1140 38-40 3 ½L water manifold new aluminum casting ea. $525.00
779 46294F (5041) oil pressure relief valve springs -fits only $0.00
780 C535 MKIV 2 ½L,3 ½L bypass hose ea. $28.00
782 SS-1 tappe cam followers (tappet) ea. $50.00
784 C365 single timing chain only ea. $23.00
811 C531R L29 replacement fan belt modern internal ribbed sytle but does the job and looks like it belongs there! ea. $34.00
850 C371 J44 bolt supporting timing cover Special double shouldered bolt supporting the timing cover on both 2 1/2, 3 1/2 litre engines. SS, MKIV, V -SUPER HARD TO FIND! ea. $23.95
857 C1890/2135 H54/55 valve springs 2.5 & 3.5 litre valve spring set of 24 set $235.00
867 C1446 D1 ,L1 oil pump this is a newly manufactured oil pump with higher capacity than the original, especially on the 2.5 litre engines-suitable for 1936- 1951 2.5/3.5 SS, Jaguar pushrod engines. comes with screen as well. ea. $610.00
Printer Friendly Version

Item Number Part Number Illus. # Part Name Description Unit Price
Item Number Part Number Illus. # Part Name Description Unit Price
28 ASS.209 H44 3 1/2 Litre engine overhaul gasket set complete: includes all gaskets for head, block & headgasket -now supplied with composite headgasket - thin copper available at $75 less cost. set $638.00
29 ASS.208 A42 2½ Litre engine overhaul gasket set complete: includes all gaskets for head, block & headgasket set $875.00
30 C337 H44 3½Litre headgaskets - SS thru MKV - these are thin copper and best installed with proper jointing compound with strict adherence to even torquing of the head bolts with the engine cold and again after it is run awhile. Two are required if you wish to retain the decompression plate used originally because of low-octane gas of the era. ea. $205.00
31 C337C Composition thick head gasket -a little more compressing ability than standard gasket! A new item made in USA! ea. $255.00
32 C346 H30 gaskets joining carbs to cylinder head set of $12.00
33 C385 H36 sump gasket for both 2½L & 3½L ea. $40.00
34 C411 K9 gaskets: water manifold to head 3½L set of $9.00
35 C457 H73 3½L cork rocker cover gasket ea. $19.00
36 C486,487,4 K3,4,5 gaskets: exhaust manifold to head 3½L 5 piece set set $45.00
37 C495 K6 gaskets: exhaust to downpipes copper/with insulation. Set of 2. set $18.00
38 C524 & C L11 gaskets: water pump and cover water pump and water pump cover gaskets. Set of 2 set $13.00
39 C586 K11 gasket: thermostat to water manifold thermometer housing to water manifold ea. $3.00
40 C810 A71 2½L cork rocker cover gasket ea. $25.00
41 1410 N4 gasket: intake manifold to carbs set of 4 set of $13.00
770 gaskets for 1 ½L, 2 ½L & 3 ½L Provide me with a tracing of what you need and we will try to match. There are mutiple variations on 1931-38 engines! $0.00
771 C337 3 ½L SS, MKIV headgasket copper headgasket ea. $235.00
772 compgasket 3 ½L SS, MKIV headgasket composition headgasket -new ea. $255.00
825 SSI 20hp headgasket old type copper jacketed with insulation between- these are shelf worn but should work fine ea. $175.00
Printer Friendly Version

Item Number Part Number Illus. # Part Name Description Unit Price
Item Number Part Number Illus. # Part Name Description Unit Price
45 C324,325 J38-39 camshaft bearings, intermediate and rear 2½L, 3½L MKIV,V set of 4 set $175.00
85 C1132 J55 big end rod bearings for 3½L STEEL rods only in sizes std., +.010, .020, .030, .040 set $80.00
86 C1144 big end rod bearings 3½L ALUMINUM alloy rods in sizes: std., +.010, .020, .030, .040. NOTE: It is not recommended to reuse your old alloy rods unless you have them properly reconditioned by an experienced shop such as a racing engine shop! Set $255.00
87 C1145 2 1/2L ONLY big end rod bearings for ALLOY RODS ONLY in sizes std., +.010, .020, .030, .040 set $255.00
88 B52 2 1/2L STEEL big end rod bearings for STEEL RODS ONLY in sizes std., +.010, .020, .030, .040 set $255.00
101 C2226 J26 bush on flywheel end of crankshaft face 2½L-3½L ea $6.00
104 C2439 small end rod bushes - steel rods -set of 6 set of $38.00
107 B12-15/J18-20 2.5/3.5 Litre engine main bearings available in +.010,020,.030,.040 only set of $495.00
Printer Friendly Version

Item Number Part Number Illus. # Part Name Description Unit Price
Item Number Part Number Illus. # Part Name Description Unit Price
113 water pump rebuild kit for MKIV,V 2.5,3.5 litre; - new shaft, gland, graphite seal, brass impellor, both hub bearings, gasket and complete detailed instructions kit $325.00
114 C705,706 L25-26 water pump bearings water pump rebuild kit set/2 $45.00
118 C3498 DZ111 upper radiator hose ea. $38.00
119 C3499 DZ112 lower radiator hose ea. $38.00
136 BD215 "L"shaped hose from return pipe to heater ea. $20.00
137 BD233 "S" shaped heater hose from return pipe to water pump banjo ea. $21.00
Printer Friendly Version

Item Number Part Number Illus. # Part Name Description Unit Price
Item Number Part Number Illus. # Part Name Description Unit Price
46 C338 exhaust valve guide 2½L, 3½L SS-MKV ea. $49.00
47 C4201 inlet valve guide 2½L, 3½L SS-MKV ea. $49.00
48 inlet valve guide, set 2½L, 3½L SS-MKV set of $575.00
58 C430 H57 split cones for valve keepers ea. $3.00
59 C433 front or rear valve tappet guide ea. $75.00
60 C434 centre valve tappet guide ea. $75.00
64 C479 H52 inlet valves for 3½L SS, MKIV, V ea. $55.00
65 C480 H53 exhaust valves for 3½L SS, MKIV, V ea. $55.00
66 H52-53 inlet & exhaust valves set of $600.00
99 H54-55 set of 24 springs set $230.00
Printer Friendly Version

Item Number Part Number Illus. # Part Name Description Unit Price
Item Number Part Number Illus. # Part Name Description Unit Price
142 Tach. Drive coupling very often the missing link to getting the tach. to work! Located between the cable and angle drive ea $35.00
785 12hp gaske 12hp/1608cc 1 -½L headgasket ea. $75.00
786 C1299 .030 rod bearings for 1.5 litre set $135.00
787 1 ½ .020 main bearings set $200.00
788 C1295 set .040 pistons with wrist pins set/4 $275.00
789 C1589 1 ½L 46-48 radiator shell badge with enamel inserts ea. $140.00
791 C3498 39-40 top radiator hose ea. $38.00
793 409635 flat top distributor cap for 1 1/2 Litre ea. $25.00
794 400052 1 ½L rotor ea. $9.00
795 400150 1 ½L distributor weight ea. $15.00
796 400415 1 ½L points ea. $15.00
797 1 ½ tuneup kit points, rotor, condensor set $30.00
853 C1103 Q.57 LH -2 eared chrome knockoff These are a quality British Made product with beautiful chrome ea. $65.00
861 1740 headlight fender mount pads These are the triangular rubber pads on the fender that the chrome headlight mount brackets sit on -they have a beaded edge with 3 holes in the rubber for the mounting bolts. pr. $51.00
873 FNR key blank New key blank for ignition, doors and gas door. We can also supply cut keys to match your FNR key code. The code is stamped into the face of the ignition switch FNR plus 1 or 2 numbers from 1-25. Cut key is $15.95 ea. $9.00